Split AC Keeps Freezing over in exercise room

[atpeace]

This has happened in 3 different homes and it only happens in my exercise room.  I sweat more than anybody I've ever seen while exercising hard.  My new( installed 4 days ago ) 1200 btu AC in a small exercise room measuring 3x4 meters and had issues today.  The indoor coils behind the air filter were frozen which was the issue in my other homes also.  

 

Would a a dehumidifier reduce the humidity significantly?  If so, any recommendations?  Maybe a second AC unit?

[transam]

Make sure water is coming out of the drain pipe to the outside................😊

[Etaoin Shrdlu]

Could be a number of issues, but I don't think it is the amount of moisture you put into the air from a workout.

 

Have the unit and filters cleaned and make sure the refrigerant is the correct pressure. Check that the drainpipe isn't blocked. 

[soi3eddie]

If the coils are freezing over, it suggests that there is not enough airflow OR that the thermostat is not cutting out when it should. Our aircon froze some years ago. Turns out it needed cleaning as the cylinder fan was clogged with dust/dirt. 

[atpeace]

3 minutes ago, Etaoin Shrdlu said:

Could be a number of issues, but I don't think it is the amount of moisture you put into the air from a workout.

 

Have the unit and filters cleaned and make sure the refrigerant is the correct pressure. Check that the drainpipe isn't blocked. 

Just put 4 days ago and worked perfectly.  This has happened with 4 ACs and only the exercise room.  I know 100% it is the moisture.  My workouts are extremely hard.  Just trying to figure out how to reduce the humidity. Thanks for the input.

[atpeace]

23 minutes ago, transam said:

Make sure water is coming out of the drain pipe to the outside................😊

Yes, been here 20 years and used many ACs. It is the humidity and looking at a solution to drop the humidity because any AC I buy will freeze over. Hmm, I once had a 21000 btu in a small room and the ac didn't freeze over so that is why I brought up buying a second unit.  My treadmill workout are hard and sweaty.

[Crossy]

Try running the unit on "dry" before you start exercise to remove existing moisture before running it on "cool".

 

Or try the other way round.

 

Run with the fan on high, not auto.

 

[atpeace]

6 minutes ago, soi3eddie said:

If the coils are freezing over, it suggests that there is not enough airflow OR that the thermostat is not cutting out when it should. Our aircon froze some years ago. Turns out it needed cleaning as the cylinder fan was clogged with dust/dirt. 

Been down this route the last 20 years.  It is because the extreme humidity causes the coils to freeze.  It happens all the time in "extreme" humidity.  I was curious if anyone had info on dehumidifiers.

[transam]

I had 2 x A/C's installed at the same time. One played up from new, water dripping, freezing up.

To cut a long story short, I got up there to investigate.

 

The unit wasn't level, plus the rubber connector to the water drain pipe was twisted, so water could not get out, then I got a bloke in to check gas pressure, it was low.

 

Been OK ever since..

[atpeace]

1 minute ago, Crossy said:

Try running the unit on "dry" before you start exercise to remove existing moisture before running it on "cool".

 

Or try the other way round.

 

Run with the fan on high, not auto.

 

Yes, that does make a difference.  Most the time it eliminates the freeze but occasionally my longer runs still cause the coils to freeze over as they did today.   Thanks and any exerience with dehumidifiers?

[atpeace]

Just now, transam said:

I had 2 x A/C's installed at the same time. One played up from new, water dripping, freezing up.

To cut a long story short, I got up there to investigate.

 

The unit wasn't level, plus the rubber connector to the water drain pipe was twisted, so water could not get out, then I got a bloke in to check gas pressure, it was low.

 

Been OK ever since..

Had those issues also but not the reason for my AC freezing over.  The same problem as the prior 4 - extreme humidity. 

[transam]

Just now, atpeace said:

Had those issues also but not the reason for my AC freezing over.  The same problem as the prior 4 - extreme humidity. 

Install an extractor fan high up a wall.........😋

[Banana7]

Low gas will cause the evaporator to freeze.

[GammaGlobulin]

13 minutes ago, Crossy said:

Try running the unit on "dry" before you start exercise to remove existing moisture before running it on "cool".

 

Or try the other way round.

 

Run with the fan on high, not auto.

 

 

This is NOT caused by excess humidity in the room, or outside the room, or outdoors.

 

The REASON the evaporator will freeze up is either it needs cleaning, OR there is a coolant leak.

 

Just in my VERY humble opinion, obviously.

 

Note:  There is also the chance that the thermostat might have been damaged, but I think this would be unlikely if the AC was functioning properly...in the past.

 

 

[GammaGlobulin]

30 minutes ago, Etaoin Shrdlu said:

Could be a number of issues, but I don't think it is the amount of moisture you put into the air from a workout.

 

Have the unit and filters cleaned and make sure the refrigerant is the correct pressure. Check that the drainpipe isn't blocked. 

 

CORRECT.

[Etaoin Shrdlu]

35 minutes ago, atpeace said:

Just put 4 days ago and worked perfectly.  This has happened with 4 ACs and only the exercise room.  I know 100% it is the moisture.  My workouts are extremely hard.  Just trying to figure out how to reduce the humidity. Thanks for the input.

 

With a new installation, I would first suspect refrigerant leak, but could be something else.

 

Let us know what the solution was once you get it sorted.

[PJ71]

joule-thomson - google it.

[atpeace]

1 hour ago, GammaGlobulin said:

 

This is NOT caused by excess humidity in the room, or outside the room, or outdoors.

 

The REASON the evaporator will freeze up is either it needs cleaning, OR there is a coolant leak.

 

Just in my VERY humble opinion, obviously.

 

Note:  There is also the chance that the thermostat might have been damaged, but I think this would be unlikely if the AC was functioning properly...in the past.

 

 

Nobody is reading my posts 🙂 It is the humidity and this is common occurrence.  The AC is a few days old and this has happened on 4 previous ACs.  The humidity is nearly 100% after 1 hour running hard on the treadmill water sometimes runs down the windows.  This happens with split ACs and I was asking if dehumidifiers might work. 

 

 

 

 

[atpeace]

1 hour ago, PJ71 said:

joule-thomson - google it.

Has zero to do with my situation. Read my OP. This happens with split AC when humidity nears 100% which it did today before freezing up as did my four prior ACs. Google will confirm what I know if you have doubts 🙂

 

Nobody has answered my OP - lol.  No problem and this is entertaining.  @Crossy did have some good ideas that do delay the freeze.  

[petermik]

Switch it off....open doors/windows and sweat like hell.....no freezing up then 👍

[Sigmund]

Run the aircon with the windows open ?

[blaze master]

2 hours ago, transam said:

I had 2 x A/C's installed at the same time. One played up from new, water dripping, freezing up.

To cut a long story short, I got up there to investigate.

 

The unit wasn't level, plus the rubber connector to the water drain pipe was twisted, so water could not get out, then I got a bloke in to check gas pressure, it was low.

 

Been OK ever since..

 

Did you pay him 200 to top up your gas.

[atpeace]

12 minutes ago, Sigmund said:

Run the aircon with the windows open ?

Actually not a bad idea if I had a 24000 btu AC in the 3x4 room.  Then again if I had put in a 24000 btu AC the coils would never freeze over because it would be able to dehumidify while cooling with the windows closed.  

[atpeace]

19 minutes ago, petermik said:

Switch it off....open doors/windows and sweat like hell.....no freezing up then 👍

Yep, and destroy the treadmill and virtual bike setup  in a month because of water damage.

[atpeace]

4 hours ago, Crossy said:

Try running the unit on "dry" before you start exercise to remove existing moisture before running it on "cool".

 

Or try the other way round.

 

Run with the fan on high, not auto.

 

This new AC's dry mode is behaving different than the previous AC.  It actually drops the humidity and the temp! Only used for 30 minutes tonight while on the treadmill - 23c and 45% humidity which is almost  ideal.  Maybe I don't need a dehumidifier 🙂